With only 2 necessary ingredients and a cooking time of about 60 seconds? Making homemade corn tortillas is much quicker and easier to make than most people expect! And even something that the most novice of home cooks can master. Once you get the hang of it, you'll never go back to store bought corn tortillas again! All you really need is masa harina and hot water. Although I tend to add a little bit of olive oil and a dash of salt for flavor.
On a large flat countertop, make a mound of masa harina. Create a crater in the middle and add olive oil and salt, if using.You don't need oil or salt. The salt is just to taste if you prefer. The oil isn't explicitly necessary, but it can help keep the dough from crumbling and usually makes working with this dough easier if you're less familiar with it.
Pour 1/2 cup hot water into the center.The key to making tortillas is using quite hot water. It should be as hot as your tap water will get (usually around 120-140 degrees Fahrenheit).
Mix together by hand, kneading dough toward the center, for 3 minutes, or until the dough begins to stick together.
Add additional hot water, 1 tablespoon at a time, and knead until the dough forms and entirely sticks together. Be careful not to add too much water. You want to add the least amount of water necessary to make the dough soft and pliable!
Cover with plastic wrap and let sit for 30 minutes.
Meanwhile, cut 3 of the 4 sides off of a plastic bag.This is NOT OPTIONAL. A plastic bag keeps the dough from sticking to the dough press and makes it easier to move the tortillas around without falling apart. You also can’t use parchment paper or plastic wrap because they aren’t elastic enough and will rip when you try to flatten out the dough. So, trust me here! And cut open a plastic bag.
Press Tortillas
After 30 minutes, form dough into 1 square-inch balls.
Place a ball of dough inside of the plastic bag and place inside of the tortilla press.It helps to place it slightly closer to the arm of the press because it will stretch outward as it flattens. If you have trouble getting the dough to flatten without squeezing out over the edge, place it slightly off of dead center!
If you aren’t using a tortilla press, place the plastic-covered dough ball on a large flat surface. Take a large baking dish with a flat bottom and press it on top of the dough until it flattens. The more weight you put into it, the flatter the dough ball will get!If it isn’t flat enough, you can roll it out further with a rolling pin. Just make sure to roll it out inside the plastic bag or it will likely stick and be a mess.
Pull the sheets of plastic apart and carefully remove the dough.If it doesn’t pull off, the dough is too thin or it has too much water. To remedy this, you can either roll the dough out a little thicker or knead more flour into it.
Cook Tortillas
Preheat a skillet on high heat.I prefer a cast iron skillet, but you can cook them any high heat pan or on the BBQ. Just make sure that there isn't any oil in the skillet, or they will deep fry and may be difficult to roll into enchiladas or whatever shape that you're going for!
If you're quick at flattening the tortillas, you may want to start the preheat before you begin so that it's already heated when you finish.I also like to have a second person flattening the tortillas as I cook them so that all of this is done in rapid succession. This isn't necessary, but you don't want the tortillas to dry out too much and it can be helpful to have a buddy here!
Place the tortilla in the center of the heated pan. Let cook for 30 seconds on each side, or until the tortilla begins to brown, but is still soft and pliable.
Cover with a towel to keep warm and pliable.If you added oil or there was some residual oil in the skillet that you cooked them in, it can help to wrap them in a paper towel first. This will keep the oil from staining your kitchen towels. Which is nearly impossible to get out!
Tips, Tricks, & Notes
If you don't have a tortilla press, make sure to use the flattening method, instead of trying to roll them out with a rolling pin! It might sound like you could flour a large surface and attempt roll them out. But the sheer amount of flour needed to do this would leave your final tortillas with a chalky texture, if you could get them to roll out without falling apart at all.
Masa harina is gluten free. However, there is a lot of potential for cross contamination during the grinding process. If you have celiac disease, make sure to find a brand of masa that doesn't use the same machinery to grind flours with gluten in them.